Mazda B-Series (B2200/B2500)

[duskylim]

Dear John:

Be Warned!

There are unscrupulous vendors out there who will sell you fake and/or used or even broken glow plugs - as some of my posts indicate I have met quite a few.

Please read the older posts as to the procedure on how to test them.

Longer plug life can be obtained by using higher voltage (12 volt) glow plugs, they take a little longer to heat but don't burn up so quickly.

If it were up to me I would want to replace the broken plug as the affected cylinder will always start 'wet' - that is it will always accumulate diesel on starting - washing out some lubrication and increasing wear.

Fordland and Fordmaster in Banawe St., carry the original KHT Kitahara's. I believe they are still around the prices I quoted.

If you do decide to replace the entire set of plugs, go whole hog and replace your glow relay too.

You can use the one for the Hyundai Starex which has an even higher ampere rating. Fordmaster has these.

Good Luck.

Best Regards,

Dusky Lim

[sniper55555]

hi guys congrats sa eb,, sayang di nanaman ako nakapunta huhuhuhu inggit naman ako, next tym sana nandun ba si csi?

[azzkkr2600]

*duskylim - Thank you. I am halfway through reading the posts. I am just using cheap glow plugs till I find out what's wrong with my engine. I guess it also boils down to the quality of the glow plugs. What can you expect from P100 plugs anyway, right? I'll try those Kitahara ones.

I am one of those, if it ain't broken, don't fix it guys. Maybe I need to do a little researching here and there about how to fix minor problems.

Thanks again.

* sir john_acha: good day sir! periodic maintenance is a must! this way, it would be a worry-free driving for you!

get the habit of opening your truck's hood every morning (or before cold starts) and check all fluid levels (and filling/refilling them if not in the max line) including belts tension.

for your engine and brakes' basic periodic maintenance, do the following: (since our trucks are more than 10years old, i recommend doing this every 3000km [instead of 5000km] or 5 months whichever comes first.)

1. oil change -- use multi grade semi syn or fully synthentic
2. oil filter -- use VIC oil filter
3. replace air filter
4. fuel filter
5. check/clean/adjust/replace brakes

6. greasing of ball joints/tie rod ends/cross joints
7. tire rotation/wheel balancing


every 10T km:
1. replace glow plugs
2. valve clearance adjustment
3. a/c cleaning (yearly) -- replace expansion valve and filter drier + evaporator flushing.
4. replace clutch belt/fan belt/alternator belt -- i do this every 2 years
5. replace transmission oil and rear axle oil -- use premium SAE90 oil
6. replace radiator fluids -- use only distilled water + coolant

sir dusky, did i miss anything? hehe.

[azzkkr2600]

* binder_clips: sir just text me kung gusto mo magpasama dun sa a/c shop. thanks!

[duskylim]

* sir john_acha: good day sir! periodic maintenance is a must! this way, it would be a worry-free driving for you!

get the habit of opening your truck's hood every morning (or before cold starts) and check all fluid levels (and filling/refilling them if not in the max line) including belts tension.

for your engine and brakes' basic periodic maintenance, do the following: (since our trucks are more than 10years old, i recommend doing this every 3000km [instead of 5000km] or 5 months whichever comes first.)

1. oil change -- use multi grade semi syn or fully synthentic
2. oil filter -- use VIC oil filter
3. replace air filter
4. fuel filter
5. check/clean/adjust/replace brakes

6. greasing of ball joints/tie rod ends/cross joints
7. tire rotation/wheel balancing


every 10T km:
1. replace glow plugs
2. valve clearance adjustment
3. a/c cleaning (yearly) -- replace expansion valve and filter drier + evaporator flushing.
4. replace clutch belt/fan belt/alternator belt -- i do this every 2 years
5. replace transmission oil and rear axle oil -- use premium SAE90 oil
6. replace radiator fluids -- use only distilled water + coolant

sir dusky, did i miss anything? hehe.

Dear Ronn:

Sir - kamusta si Misis?

Mainit pa ba ulo?

Anyway, I hope you will recover from your injuries soon.

We are all praying for you.

Hoy! Joke only.

Tama ka sir!

You're even more extreme than me sa maintenance - I stick to the 5,000 km change and use regular (non-synthetic oils).

Changing at 3,000 km is HARDCORE! (and expensive).

Keep on Trucking!!!

Best Regards,

Dusky Lim

[azzkkr2600]

[SIZE=3]more photos![/SIZE]


gerivic / B2500. 4x4. flatblack extended fenders & rear bumper. new mags.



ebasreb / B2600i. 4x4. A/T. all orig US ver.



binder_clips / B2500. 4x2. newly painted.



abysstone / B2200. 4x2. local. custom 2-dr cabplus.



pigface / B2500. 4x4. work in progress. new paint. 2-inch bodylift. ironman shocks. tsl swampers. custom 199ORH A-arms and front & rear bumpers.

[chinesecarebear]

* pigface

malapit mo ng maenjy sir yun ride mo

[azzkkr2600]

ken / B2200. 4x2. stock? sorry di ko nabutingting. sa next EB dapat sa may shady area tayo. hehe.

[duskylim]

Hi Guys:

Samantalhin ko na yung pagkakataon - if you guys are really serious about doing a little under-the-hood work, we should have access to a well-equipped repair shop, otherwise bad things could happen.

Ngayon kailangan mag-isip ng malalim kung saan tayo pwedeng mag-kalikot.

Just my 2 cents.

Best Regards,

Dusky Lim

[chinesecarebear]

Hi Guys:

Samantalhin ko na yung pagkakataon - if you guys are really serious about doing a little under-the-hood work, we should have access to a well-equipped repair shop, otherwise bad things could happen.

Ngayon kailangan mag-isip ng malalim kung saan tayo pwedeng mag-kalikot.

Just my 2 cents.

Best Regards,

Dusky Lim

+1 with sir dusky. mas masaya kung may shop tayong pwedeng tambayan. pwede tayong magshare and learn with regards our ride. even I wanted to learn more.

wala lang kahutahan. ^_^

Truck and RoLL,

[azzkkr2600]

guys, any suggestions?

[csi28]

hi guys congrats sa eb,, sayang di nanaman ako nakapunta huhuhuhu inggit naman ako, next tym sana nandun ba si csi?

masyado ka na naman busy raket negosyo mo bro...di ako nakapunta pero next eb sana dun na ako with my hopefully new ride (b25)...

*ronn and sir dusky...tnx for keeping the group alive.re enroll ako sa next eb.hehe.actually hunting ako b25 ngayon.

* all...nice seeing your trucks mga sir...hope to see you all again sa next eb.


TRUCK LOVE!!

[csi28]

road trip next eb para maiba...tagaytay,batangas,etc..hehe.

[azzkkr2600]

yan din suggestion ni sir gerivic nun last EB. saturday tayo kita kits then overnight sa isang resort.

[duskylim]

yan din suggestion ni sir gerivic nun last EB. saturday tayo kita kits then overnight sa isang resort.

Ronn:

A great idea, and I would like to add that we use the occasion to undertake check-ups BEFORE we drive - whaddaya think?

In fact, we would really need a place where we could have access to tools, air, etc, where each truck could be inspected/checked.

Lets just do the basics - say linis ng air cleaners, check tire pressure, bleed air from fuel systems, etc.

We could also do that once we arrive at the place on the way back - nasa inyo talaga.

Anyone have ideas on where that could be?

Dusky Lim

[duskylim]

Hi Guys!

Yes (or Oh No!!!) it's me again, with interesting articles for you to read.

I was browsing through my favorite on-line auto magazine and came across these articles:

http://autospeed.com.au/cms/A_111486/article.html

http://autospeed.com.au/cms/A_111369/article.html

Go ahead and click on the link - you will find these VERY Interesting.

Keep on Trucking!!!

Dusky Lim

[gerivic]

Ronn:

A great idea, and I would like to add that we use the occasion to undertake check-ups BEFORE we drive - whaddaya think?

In fact, we would really need a place where we could have access to tools, air, etc, where each truck could be inspected/checked.

Lets just do the basics - say linis ng air cleaners, check tire pressure, bleed air from fuel systems, etc.

We could also do that once we arrive at the place on the way back - nasa inyo talaga.

Anyone have ideas on where that could be?

Dusky Lim

Sir Ronn/Sir Dusky,

Good PM. Ganda idea yan suggestion ko sa nasugbu bats. dami resort dun lapit lng yun,try ko contact yun pinuntahan namin last summer outing namin. update ko kayo asap. Regarding place to do our check - up before the trip, ala ako ma-icip na place. Wait natin yun iba baka may suggestion sila place. Beep ! Beep ! Any suggestion ???

[azzkkr2600]

ganito gayahin mo sir abysstone!



nardong putik! hehe!



anyone who wants to order?

[azzkkr2600]

parang ganito kakalabasan ng project truck ni sir pigface... TSL swampers baby!!

[chinesecarebear]

* ronn

maganda yun smoke. ang galing naman. san ka nga pla o-order nyan? available ba dito yan?

* sir gerivic

diba may barge na tumaob sa nasugbo? hoping yun makita natin eh malayo sa pinatapunan ng mga coals.